Stability of a highly concentrated solution of epirubicin for conventional transcatheter arterial chemoembolization.

Epirubicin is widely used for conventional transcatheter arterial chemoembolization (cTACE) in patients with hepatocellular-carcinoma. However, there is no data about its stability in solution at concentration higher than 2 mg/L, yet needed when mixing it with a standard volume of Lipiodol(®) to produce an efficient water-in-oil emulsion. The aim of this study was therefore to evaluate the stability of a highly concentrated solution of epirubicin for cTACE and verify whether epirubicin solution could be prepared in advance. Fifty milligrams of epirubicin were dissolved in 6 mL of 0.9% sodium chloride and conditioned in brown polypropylene syringe. Physical and chemical stability assays including particles and HPLC-DAD analysis were performed in triplicate, using series of 5 syringes stored over 72 h at 4±2 °C followed by 4h at 22±4°C. Neither weight loss nor pH or spectrum change occurred. No haze or turbidity was observed and the number of subvisible particles was below the recommended limits. Epirubicin concentration remained above 95% of the initial value over the 72 h of storage at +4 °C followed by 4h at 22±4 °C and no degradation was observed. Epirubicin at 50mg/6 mL in 0.9% NaCl conditioned in brown propylene syringe is stable for at least 72 h at 4±2 °C with additional 4h at 22±4 °C allowing its preparation in advance for programmed cTACE and the standardization of its use in clinical practice.